行业动态

当前位置:网站首页 >> 新闻资讯 >> 行业动态 >> 查看详情

行业动态

如何让空压机发挥最大效率

来源:杭州优联超滤设备有限公司  日期:2019-08-29 11:35:40  点击:627  属于:行业动态
1、在使用空压机之前,您应该仔细翻阅空压机使用手册。 2、要想有效的节省电能,用户就要注意空压机房的通风散热,空压机房环境温度过高,相当于降低了空压机效率,排气量减少,能耗增加。环境温度每升高100°C,相当于空压机效率降低越3%。
1、在使用空压机之前,您应该仔细翻阅空压机使用手册。
 
2、要想有效的节省电能,用户就要注意空压机房的通风散热,空压机房环境温度过高,相当于降低了空压机效率,排气量减少,能耗增加。环境温度每升高100°C,相当于空压机效率降低越3%。
 
3、另外空压机机房要保持干净,整洁。空压机房环境过脏,容易造成空压机的滤清器,油过滤器,油气分离器堵塞,润滑油加速污染,更换频繁。
 
4、对空压机进行定期保养,尽量使用原厂配件。如果空压机保养不善或长期不保养,小问题就会日积月累成大故障,机器寿命人为缩短。
 
5、空压机尽量集中供气。如果空压机分散配置在全厂各地,管线独立,既增加购置成本,也增加了管线成本和运行维护费用。特别是如果管道漏气严重而没有及时发现,以为用气量不足了,用新购空压机来补充不足的用气量,造成浪费,以一处7 kg/cm2g,10 mm泄漏点计算,假定电费人民币1元/度,一年8000小时将浪费32万人民币的电费。
1, before using the air compressor, you should read the air compressor manual carefully.
 
 
 
2, in order to effectively save energy, users should pay attention to the air compressor room ventilation heat dissipation, air compressor room environment temperature is too high, equivalent to reduce the efficiency of air compressor, reduce the exhaust volume, increase energy consumption. Every 100°C increase in ambient temperature is equivalent to a 3% decrease in air compressor efficiency.
 
 
 
3, in addition, the air compressor room to keep clean and tidy. Air compressor room environment is too dirty, easy to cause air compressor filter, oil filter, oil and gas separator clogging, lubricating oil pollution acceleration, frequent replacement.
 
 
 
4, the air compressor for regular maintenance, try to use the original factory accessories. If the air compressor maintenance is not good or long-term maintenance, small problems will accumulate into a major failure, the life of the machine artificially shortened.
 
 
 
5, air compressor as far as possible centralized air supply. If the air compressor is distributed throughout the plant, independent pipeline, not only increase the purchase cost, but also increase the pipeline cost and operation and maintenance costs. Especially if the pipeline leakage is serious and not found in time, because the gas consumption is insufficient, the air compressor is newly purchased to supplement the insufficient gas consumption, resulting in waste. The calculation is based on a leakage point of 7 kg/cm2g and 10 mm, assuming that the electricity cost is 1 yuan/KWH, a year 8000 hours will waste the electricity cost of 320,000 yuan.